Quadra-Fire 4300 Series Operations Instructions download pdf

4300 WOOD STOVE SERIES

Advanced Combustion Technology (ACT)

1445 North Highway

Colville, WA 99114

SAVE THESE INSTRUCTIONS

Part 250-7061C December 10, 2004

www.quadraﬁre.com

PRIOR TO FIRST FIRE

: Remove all labels from glass. Clean plated surfaces with a glass cleanser and soft cloth to

prevent staining from ﬁngerprint oils.

O-T L

Tested and

Listed by

Beaverton

Oregon USA

OMNI-Test Laboratories, Inc.

This manual contains instructions for Installation, Operation & Maintenance. Please read this entire

manual before you install and use your new room heater. Failure to follow instructions may result in

property damage, bodily injury, or even death.

MILLENNIUM

STEP TOP UNI-BODY

IMPORTANT SAFETY NOTES:

1) When installing your stove, particular attention should be paid to ﬁre protection. If this room heater is not properly

installed, a house ﬁre may result. To reduce the risk of ﬁre, follow the installation instructions. Contact local building,

ﬁre ofﬁcials or authority having jurisdiction about restrictions, installation inspection and permit requirements in your

area.

2) CAUTION: Never use gasoline, gasoline-type lantern fuel, kerosene, charcoal lighter ﬂuid, or similar liquids to start

or “freshen up” a ﬁre in this heater. Keep all such liquids well away from the heater while it is in use.

3) During operation, if any part of the stove starts to glow, the stove is in an overﬁred condition. Close the air controls

completely by pulling them out, until the glowing has stopped. OVERFIRING VOIDS YOUR WARRANTY!

4) Cool ashes should be disposed of carefully, using a metal container.

5) Do not burn wet or green wood. Store wood in a dry location.

6) DO NOT BURN GARBAGE OR FLAMMABLE FLUIDS SUCH AS GASOLINE, NAPHTHA OR ENGINE OIL. Do not

burn treated wood, or wood with salt (driftwood, etc.). Burning materials other than wood (including charcoal) under

adverse conditions may generate carbon monoxide in the home, resulting in illness or possible death.

7) Do not permit creosote or soot to accumulate excessively in the chimney or inside the ﬁrebox.

8) Check your chimney system thoroughly when installing into an existing metal or masonry chimney. Seek profes-

sional advice if in doubt about its condition.

9) Do not connect this unit to a chimnney ﬂue already serving another appliance.

10) Comply with all minimum clearances to combustibles as shown in this manual for this appliance.

11) Build ﬁre on brick ﬁrebox ﬂoor. Do not use grates, andirons or other methods to support fuel.

12) HOT WHILE IN OPERATION! Keep children, pets, clothing and furniture away. Contact can cause skin burns.

13) Do not connect to any air distribution duct or system.

14) RISK OF FIRE! Do not operate with stove door or ash removal system door open.

15) For further information refer to NFPA 211 (USA) or CAN/CSA-B365 (Canada).

16) Do not operate without fully assembling all components. Burning your stove wthout the legs attached (if supplied

with unit) will void your warranty, and could present a serious safety hazard.

17) Do not operate with broken glass.

VERY IMPORTANT!!

BEFORE STARTING YOUR

FIRST FIRE READ

HOW TO OPERATE THE

2-STEP DOOR HANDLE

ON PAGE 20

1 2 ... 32

Summary of Contents

Page 1 - 4300 WOOD STOVE SERIES

4300 WOOD STOVE SERIESAdvanced Combustion Technology (ACT)1445 North HighwayColville, WA 99114SAVE THESE INSTRUCTIONS Part 250-7061C Decemb

Page 2

4300 ACT Wood Stove SeriesPage 10 250-7061C December 10, 2004RTo be sure that your Quadra-Fire stove burns properly, the chimney draft (static pres

Page 3 - TABLE OF CONTENTS

Page 11 250-7061C December 10, 20044300 ACT Wood Stove SeriesRThere are two separate and different parts to a ﬂue system: the chimney connector and

Page 4

4300 ACT Wood Stove SeriesPage 12 250-7061C December 10, 2004RFIGURE 12BSOLID PACK CHIMNEY WITH METAL SUPPORTS AS A THIMBLEFor the method of inst

Page 5 - DIMENSIONS

Page 13 250-7061C December 10, 20044300 ACT Wood Stove SeriesRFirst, make the frame for the thimble, ensur-ing it is no smaller than 14" (356m

Page 6 - 4300 MILLENNIUM MODEL

4300 ACT Wood Stove SeriesPage 14 250-7061C December 10, 2004R**FloorProtectorChimney ConnectorCombustibleCeilingCombustible WallInsulated " T

Page 7

Page 15 250-7061C December 10, 20044300 ACT Wood Stove SeriesRSpark Arestor CapRoof FlashingStorm CollarJoist Shield/FirestopDouble wallconnector p

Page 8

4300 ACT Wood Stove SeriesPage 16 250-7061C December 10, 2004R1. Place protective pad or stove pallet on ﬂoor.2. Lay body of stove on its back on

Page 9 - FLOOR PROTECTION (Cont’d)

Page 17 250-7061C December 10, 20044300 ACT Wood Stove SeriesRPEDESTAL MODEL1 Place protective pad or stove pallet on ﬂoor.2. Lay body of stove

Page 10 - CHIMNEY HEIGHT/DRAFT

4300 ACT Wood Stove SeriesPage 18 250-7061C December 10, 2004RBLOWER SPEED CONTROLBlower Mounting FlangeOuter SkinINSTALLATION OF OPTIONAL BLOWER,

Page 11 - MASONRY CHIMNEY (Cont’d)

Page 19 250-7061C December 10, 20044300 ACT Wood Stove SeriesR(Cut-away view)FRONT COVERSIDE COVER (2)4" (102mm) FLEX LINE (Not Included)FLEX

Page 12

4300 ACT Wood Stove SeriesPage 2 250-7061C December 10, 2004R___________________________Alan TruslerSenior Vice PresidentDealer Channel____________

Page 13

4300 ACT Wood Stove SeriesPage 20 250-7061C December 10, 2004RSTART-UP AIRCONTROLPRIMARY AIRCONTROLBURNING PROCESSIn recent years there has been an

Page 14

Page 21 250-7061C December 10, 20044300 ACT Wood Stove SeriesRNOTE: These are approximate settings, and will vary with type of wood or chimney dra

Page 15 - MOBILE HOME INSTALLATION

4300 ACT Wood Stove SeriesPage 22 250-7061C December 10, 2004ROPACITYThis is the measure of how cleanly your stove is burning. Opacity

Page 16 - ARS OPERATING AND CLEANING

Page 23 250-7061C December 10, 20044300 ACT Wood Stove SeriesRMAINTENANCE and GLASS CAREDISPOSAL OF ASHESAshes should be placed in a metal co

Page 17 - SAFETY HAZARD

4300 ACT Wood Stove SeriesPage 24 250-7061C December 10, 2004R113113111111114223311BRICK REPLACEMENT INSTRUCTIONSThe Step-Top Model accepts the Ash

Page 18 - Part: 831-0972

Page 25 250-7061C December 10, 20044300 ACT Wood Stove SeriesRFIGURE 25C - Bafﬂe and Ceramic Blanket .Fiberboard BaffleCeramic BlanketAllen wrench

Page 19 - Part 831-1780

4300 ACT Wood Stove SeriesPage 26 250-7061C December 10, 2004R17.0"(432mm)19.0" (483mm)Ceramic Blanket123456789101112Item Part Name1

Page 20 - AIR CONTROLS

Page 27 250-7061C December 10, 20044300 ACT Wood Stove SeriesR831-1671 . . . . . . . .Ash Removal System (ARS)831-1701 . . . . . . . .Blower Asse

Page 21 - BUILDING A FIRE

4300 ACT Wood Stove SeriesPage 28 250-7061C December 10, 2004RNOTES

Page 22

Page 29 250-7061C December 10, 20044300 ACT Wood Stove SeriesRNOTES

Page 23 - DISPOSAL OF ASHES

Page 3 250-7061C December 10, 20044300 ACT Wood Stove SeriesRMODEL NAME Uni-Body: ___Step Top ___ MillenniumSerial NumberDate

Page 24

4300 ACT Wood Stove SeriesPage 30 250-7061C December 10, 2004RDate of Service Performed By Description of ServiceService and Maintenance Log

Page 25 - DOOR HANDLE ASSEMBLY

Page 31 250-7061C December 10, 20044300 ACT Wood Stove SeriesRLIMITED LIFETIME WARRANTYThe Hearth & Home Technologies limited Lifetime Warranty

Page 26 - EXPLODED VIEWS

250-7061C December 10, 2004Page 32RATTENTION INSTALLERS:PLEASE RETURN THESE INSTRUCTIONS TO THE HOME OWNER WHEN THE INSTALLATION IS COMPLETE This pr

Page 27 - Base Options

4300 ACT Wood Stove SeriesPage 4 250-7061C December 10, 2004RLISTINGS & SAFETY CAUTIONSThese installation instructions describe the instal

Page 28

Page 5 250-7061C December 10, 20044300 ACT Wood Stove SeriesRDIMENSIONS 26-1/2" (673mm)34-1/4" (870mm)10-1/2" (267mm)15.0" (381

Page 29

4300 ACT Wood Stove SeriesPage 6 250-7061C December 10, 2004RDIMENSIONS 4300 MILLENNIUM MODELCL21.0" (533mm)14-15/16" (379mm)10-15/16&quo

Page 30 - Service and Maintenance Log

Page 7 250-7061C December 10, 20044300 ACT Wood Stove SeriesRGH*90° OFF TOP UP & OUT CEILING CLEARANCESTOVE TO CEILING CLEARANCE CLEARANCES TO

Page 31 - Lifetime Warranty

4300 ACT Wood Stove SeriesPage 8 250-7061C December 10, 2004RFLOOR PROTECTION: Floor protector must be noncombustible material, extending

Page 32 - ATTENTION INSTALLERS:

Page 9 250-7061C December 10, 20044300 ACT Wood Stove SeriesRR =x T1kR =x T1K x 12k-factor is given with a required thickness (T) in inches: K-fact

Comments to this Manuals

No comments

Quadra-Fire 4300 Series Operations Instructions

Browse online or download Operations Instructions for Fireplaces Quadra-Fire 4300 Series. Quadra-Fire 4300 Series Operating instructions User Manual

Summary of Contents

Comments to this Manuals

Related products and manuals for Fireplaces Quadra-Fire 4300 Series