Rwww.quadrare.com7001-142DSeptember 1, 2008SANTA FE PELLET STOVEOwner’s ManualInstallation and OperationSANTAFE-B1Model: HOT! DO NOT TOUCH. SEVERE BU
Page 107001-142DSeptember 1, 2008Santa Fe Pellet Stove R RR Do not terminate vent in any enclosed or semi-enclosed area such as a carport, garage, at
R R RSeptember 1, 20087001-142DPage 11Santa Fe Pellet Stove Improper installation, adjustment, alteration, service or maintenance can cause injury or
Page 127001-142DSeptember 1, 2008Santa Fe Pellet Stove R RR 5Venting SystemsNOTE:• Illustrations reect typical installations and are FOR DESIGN PUR
R R RSeptember 1, 20087001-142DPage 1Santa Fe Pellet Stove B. Through The WallHorizontal termination cap must be a minimum of 12 inches. (05mm) fr
Page 147001-142DSeptember 1, 2008Santa Fe Pellet Stove R RR We recommend a minimum of 60 in. (1524mm) vertical, however above the eave is p
R R RSeptember 1, 20087001-142DPage 15Santa Fe Pellet Stove Fire RiskInspection of Chimney:• Masonry chimney must be in good condition.• Meets mini
Page 167001-142DSeptember 1, 2008Santa Fe Pellet Stove R RR 6Mobile Home1. An outside air inlet must be provided for the combustion air and must rem
R R RSeptember 1, 20087001-142DPage 17Santa Fe Pellet Stove 7Appliance Set-UpA. Outside Air Kit Instructions Flex HoseHose ClampCollar AssemblyTrim R
Page 187001-142DSeptember 1, 2008Santa Fe Pellet Stove R RR 3 to 3 inch Top Vent Adapter 3 to 6 inch Top Vent Offset Adapter 1. Put a layer of hig
R R RSeptember 1, 20087001-142DPage 19Santa Fe Pellet Stove D. Optional Log Set Placement InstructionsFigure 19.14 PIECE LOG SET INSTALLATIONOPTIONA
Page 27001-142DSeptember 1, 2008Santa Fe Pellet Stove R RR Hearth & Home Technologies welcomes you to our tradi-tion of excellence! In choosing
Page 207001-142DSeptember 1, 2008Santa Fe Pellet Stove R RR E. Optional Gold or Nickel Grille & Trim Ring1. While holding door to face, rem
R R RSeptember 1, 20087001-142DPage 21Santa Fe Pellet Stove 1. A 12 volt AC thermostat is required to operate this pellet appliance. You may use th
Page 227001-142DSeptember 1, 2008Santa Fe Pellet Stove R RR 8Operating InstructionsA. Fuel Size And Material1. Wood PelletsFuel pellets are made fro
R R RSeptember 1, 20087001-142DPage 2Santa Fe Pellet Stove Figure 23.1E. Fire CharacteristicsA properly adjusted re with the heat output control s
Page 247001-142DSeptember 1, 2008Santa Fe Pellet Stove R RR G. Iginition Cycles1. During each ignition cycle, it is normal to see some smo
R R RSeptember 1, 20087001-142DPage 25Santa Fe Pellet Stove 9TroubleshootingWith proper installation, operation, and maintenance your appliance will
Page 267001-142DSeptember 1, 2008Santa Fe Pellet Stove R RR Symptom Possible Cause Corrective ActionSlow or smoky start-up (Cont’d)Dirty exhaust and/
R R RSeptember 1, 20087001-142DPage 27Santa Fe Pellet Stove Symptoms Possible Cause Corrective ActionConvection blower fails to start.#1 snap disc de
Page 287001-142DSeptember 1, 2008Santa Fe Pellet Stove R RR 10Maintaining & Servicing Your ApplianceC. General Maintenance1. Types of Fuel Depe
R R RSeptember 1, 20087001-142DPage 29Santa Fe Pellet Stove WARNING• The cleaning slide plates must be fully CLOSED when appliance is operating. H
R R RSeptember 1, 20087001-142DPage Santa Fe Pellet Stove Section 1: Listing and Code Approvals A. Appliance Certications ...4
Page 07001-142DSeptember 1, 2008Santa Fe Pellet Stove R RR Figure 30.2Vacuum insideExhaust VentingCleaning Rods10 Heat Exchanger TubesThe amount o
R R RSeptember 1, 20087001-142DPage 1Santa Fe Pellet Stove 11. Cleaning the Glass• Frequency: When clear view of the repot becomes obscure• By:
Page 27001-142DSeptember 1, 2008Santa Fe Pellet Stove R RR B. High Ash Fuel Content Maintenance• Frequency: As needed• By: HomeownerCorrect Flam
R R RSeptember 1, 20087001-142DPage Santa Fe Pellet Stove 1. Convection Blower Replacementa. Turn down the thermostat, let appliance completely c
Page 47001-142DSeptember 1, 2008Santa Fe Pellet Stove R RR NOTE: Combustion Blower Gasket is also required. Sold separately under Part Number 240-
R R RSeptember 1, 20087001-142DPage 5Santa Fe Pellet Stove D. Igniter ReplacementE. Bafe & Brick Removal 1. Shut down the appliance by turn
Page 67001-142DSeptember 1, 2008Santa Fe Pellet Stove R RR F. Bafe & Brick ReplacementRight Brick InstalledBrick is flush against back wallBri
R R RSeptember 1, 20087001-142DPage 7Santa Fe Pellet Stove G. Glass Replacement• Glass is 5mm thick high temperature heat-resistant ceramic glass.
Page 87001-142DSeptember 1, 2008Santa Fe Pellet Stove R RR 11Reference Materials7. Heat ExchangersThe heat exchangers transfer hot air from the exh
R R RSeptember 1, 20087001-142DPage 9Santa Fe Pellet Stove 16. Snap Disc #1 (Convection Blower) 110°FSnap disc #1 is located on the right side of t
Page 47001-142DSeptember 1, 2008Santa Fe Pellet Stove R RR 1Listing and Code ApprovalsA. Appliance CerticationC. Glass SpecicationsE. BTU &
Page 407001-142DSeptember 1, 2008Santa Fe Pellet Stove R RR B. Component LocationsRed Call LightFuseControlBoxVacuumSwitchJunction BoxHighMedLowHeat
R R RSeptember 1, 20087001-142DPage 41Santa Fe Pellet Stove Figure 41.1 - Door, Face, Glass & Door Latch Assembly256556755Figure 41.2 - Firepot
Page 427001-142DSeptember 1, 2008Santa Fe Pellet Stove R RR Figure 42.139 31 30 32 33 34 35 36 37 38 40 41 42 43 44 45 46 47 49 50 51 52 53 54 55 56
R R RSeptember 1, 20087001-142DPage 4Santa Fe Pellet Stove D. Service Parts and AccessoriesItem # Service Parts Description Part NbrAsh Catcher 700
Page 447001-142DSeptember 1, 2008Santa Fe Pellet Stove R RR Accessory Description Part NumberGrille, Louver, Gold LVGRL-SF-GDGrille, Louver, Nickel
R R RSeptember 1, 20087001-142DPage 45Santa Fe Pellet Stove Date of Service Performed By Description of ServiceE. Service And Maintenance Log
Page 467001-142DSeptember 1, 2008Santa Fe Pellet Stove R RR F. Warranty PolicyHearth & Home Technologies LIMITED WARRANTYHearth & Home Techn
R R RSeptember 1, 20087001-142DPage 47Santa Fe Pellet Stove Noise resulting from minor expansion, contraction, or movement of certain parts is nor
RHearth & Home Technologies1445 North HighwayColville, WA 99114Division of HNI INDUSTRIES7001-142D September 1, 2008Page 48CONTACT INFORMATION:P
R R RSeptember 1, 20087001-142DPage 5Santa Fe Pellet Stove 2Getting StartedA. Design, Installation & Location Considerations1. Appliance Locatio
Page 67001-142DSeptember 1, 2008Santa Fe Pellet Stove R RR D. Inspect Appliance & Components and Pre-Use Check ListReciprocating SawChannel Locks
R R RSeptember 1, 20087001-142DPage 7Santa Fe Pellet Stove 3Dimensions and ClearancesA. Appliance DimensionsFigure 7.2- Front ViewFigure 7.1 - Top
Page 87001-142DSeptember 1, 2008Santa Fe Pellet Stove R RR Straight Back Against WallInches MillimetersABack Wall to Appliance 2 51BSide Wall to App
R R RSeptember 1, 20087001-142DPage 9Santa Fe Pellet Stove *L Exception for Horizontal Installations:USA INSTALLATIONS: If optional Cast Base is inst
Comments to this Manuals