Quadra-Fire CASTILEI-MBK Owner's Manual

R www.quadrafi re.com 7021-130C November 21, 2011CASTILE-B PELLET STOVEO-T LTested and Listed byPortlandOregon USAOMNI-Test Laboratories, Inc.CUSOwner’

Page 107021-130CNovember 21, 2011R Castile-B FS Pellet Stove *L Exception for Horizontal Installations:See Figure 10 2USA INSTALLATIONS: A non-combus

R November 21, 20117021-130CPage 11Castile-B FS Pellet Stove Do not terminate vent in any enclosed or semi-enclosed area such as a carport, garage, a

Page 127021-130CNovember 21, 2011R Castile-B FS Pellet Stove Improper installation, adjustment, alteration, service or maintenance can cause injury o

R November 21, 20117021-130CPage 13Castile-B FS Pellet Stove 5Venting SystemsNOTE:• Illustrations refl ect typical installations and are FOR DESIGN P

Page 147021-130CNovember 21, 2011R Castile-B FS Pellet Stove 6 in. (152mm) MinimumNon-combustible Hearth PadWall Thimble Horizontal Termination Cap2

R November 21, 20117021-130CPage 15Castile-B FS Pellet Stove We recommend a minimum of 60 in. (1.5m) vertical, however above the eave is prefer

Page 167021-130CNovember 21, 2011R Castile-B FS Pellet Stove Fire HazardInspection of Chimney:• Masonry chimney must be in good condition.• Meets m

R November 21, 20117021-130CPage 17Castile-B FS Pellet Stove 6Mobile Home1. An outside air inlet must be provided for the combustion air and must re

Page 187021-130CNovember 21, 2011R Castile-B FS Pellet Stove 7Appliance Set-UpA. Outside Air Kit Instructions Parts Included in Kit: 1 piece of 2 inc

R November 21, 20117021-130CPage 19Castile-B FS Pellet Stove 3 to 3 inch Top Vent Adapter 3 to 6 inch Top Vent Offset Adapter 1. Put a layer of hi

Page 27021-130CNovember 21, 2011R Castile-B FS Pellet Stove Hearth & Home Technologies welcomes you to our tradition of excellence! In choosi

Page 207021-130CNovember 21, 2011R Castile-B FS Pellet Stove E. Optional Log Set Placement Instructions4 PIECE LOG SET INSTALLATIONFigure 20.1CAUTIO

R November 21, 20117021-130CPage 21Castile-B FS Pellet Stove 1. A 12 volt AC thermostat is required to operate this pellet appliance. You may use t

Page 227021-130CNovember 21, 2011R Castile-B FS Pellet Stove 8Operating InstructionsA. Fuel Size, Material and Storage1. Wood PelletsFuel pellets ar

R November 21, 20117021-130CPage 23Castile-B FS Pellet Stove HighMedLowHeat Output SwitchReset ButtonReset ButtonC. Before Your First Fire1. First,

Page 247021-130CNovember 21, 2011R Castile-B FS Pellet Stove Figure 24.1E. Fire CharacteristicsA properly adjusted fi re with the heat output control

R November 21, 20117021-130CPage 25Castile-B FS Pellet Stove H. Frequently Asked Questions Odors and vapors released during initial operation.• Cur

Page 267021-130CNovember 21, 2011R Castile-B FS Pellet Stove 9TroubleshootingWith proper installation, operation, and maintenance your appliance will

R November 21, 20117021-130CPage 27Castile-B FS Pellet Stove Symptom Possible Cause Corrective ActionSlow or smoky start-up (Cont’d)Dirty exhaust and

Page 287021-130CNovember 21, 2011R Castile-B FS Pellet Stove Symptoms Possible Cause Corrective ActionConvection blower fails to start.#1 snap disc d

R November 21, 20117021-130CPage 29Castile-B FS Pellet Stove 10Maintaining & Servicing Your ApplianceC. General Maintenance1. Types of Fuel Dep

R November 21, 20117021-130CPage 3Castile-B FS Pellet Stove TABLE OF CONTENTS Safety Alert Key:• DANGER! Indicates a hazardous situation which,

Page 307021-130CNovember 21, 2011R Castile-B FS Pellet Stove 2. Cleaning Firepot with Cleaning Rod & Firepot Scraper• Frequency: Daily or more

R November 21, 20117021-130CPage 31Castile-B FS Pellet Stove 7. Cleaning Heat Exchanger Chambers & Drop Tube• Frequency: Monthly or every 1 to

Page 327021-130CNovember 21, 2011R Castile-B FS Pellet Stove Clean-Out CoverFigure 32.114. Cleaning the Top Vent Adaptera. The appliance must be in

R November 21, 20117021-130CPage 33Castile-B FS Pellet Stove Correct Flame Size, Yellow/White in ColorCorrectFigure 33.3Tall, Lazy Flame, Orange in C

Page 347021-130CNovember 21, 2011R Castile-B FS Pellet Stove Combustion BlowerRemove 6 screwsFigure 34.2Figure 34.31. Combustion Blower ReplacementN

R November 21, 20117021-130CPage 35Castile-B FS Pellet Stove G. Baffl e & Brick Set Removal2. Convection Blower Replacementa. Turn down thermo

Page 367021-130CNovember 21, 2011R Castile-B FS Pellet Stove I. Glass Replacement• Glass is 5mm thick high temperature heat-resistant ceramic glass

R November 21, 20117021-130CPage 37Castile-B FS Pellet Stove 11Reference MaterialsWhen describing the location of a component, it is always AS YOU FA

Page 387021-130CNovember 21, 2011R Castile-B FS Pellet Stove 16. ThermostatThe appliance is designed to run on a 12 volt AC thermostat. The heat a

R November 21, 20117021-130CPage 39Castile-B FS Pellet Stove B. Component LocationsFigure 39.1Figure 39.2Figure 39.3Convection Blower & HousingFe

Page 47021-130CNovember 21, 2011R Castile-B FS Pellet Stove 1Listing and Code ApprovalsA. Appliance Certifi cationE. BTU & Effi ciency Specifi cat

Page 407021-130CNovember 21, 2011R Castile-B FS Pellet Stove C. Exploded DrawingFigure 40.1Service Parts12345678910111213141516171819202122232430252

R November 21, 20117021-130CPage 41Castile-B FS Pellet Stove Service PartsIMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacemen

Page 427021-130CNovember 21, 2011R Castile-B FS Pellet Stove Service PartsIMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacemen

R November 21, 20117021-130CPage 43Castile-B FS Pellet Stove Service PartsIMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacemen

Page 447021-130CNovember 21, 2011R Castile-B FS Pellet Stove Service PartsIMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacemen

R November 21, 20117021-130CPage 45Castile-B FS Pellet Stove Service PartsIMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacemen

Page 467021-130CNovember 21, 2011R Castile-B FS Pellet Stove E. Warranty Policy

R November 21, 20117021-130CPage 47Castile-B FS Pellet Stove

R Hearth & Home Technologies1445 North HighwayColville, WA 99114Division of HNI INDUSTRIES7021-130C November 21, 2011Page 48CONTACT INFORMATION:

R November 21, 20117021-130CPage 5Castile-B FS Pellet Stove 2Getting StartedA. Design, Installation & Location Consider-ationsWarning! Risk of Fi

Page 67021-130CNovember 21, 2011R Castile-B FS Pellet Stove C. Thermostat LocationThe thermostat’s location will have some effect on the appl

R November 21, 20117021-130CPage 7Castile-B FS Pellet Stove H. Inspect Appliance & Components and Pre-Use Check ListReciprocating SawChannel Lock

Page 87021-130CNovember 21, 2011R Castile-B FS Pellet Stove 3Dimensions and ClearancesA. Appliance DimensionsFigure 7.2- Front ViewFigure 7.1 - Top

R November 21, 20117021-130CPage 9Castile-B FS Pellet Stove Straight Back Against WallInches MillimetersABack Wall to Appliance 2 51BSide Wall to Ap