Quadra-Fire Isle Royale User Manual download pdf

SAVE THESE INSTRUCTIONS

www.quadraﬁre.com

This manual contains instructions for Installation, Operation & Maintenance.

Please read this entire manual before you install and use your new room heater. Failure to follow

instructions may result in property damage, bodily injury, or even death.

Isle Royale

Non-Catalytic, Top-load, Wood Heater

O-T L

Tested and

Listed by

Beaverton

Oregon USA

OMNI-Test Laboratories, Inc.

250-5763B February 4, 2005

PRIOR TO FIRST FIRE: Remove all labels from glass. Clean plated surfaces with a glass cleanser and soft

cloth to prevent staining from ﬁngerprint oils.

IMPORTANT SAFETY NOTES:

1) When installing your stove, particular attention should be paid to ﬁre protection. If this room heater is not

properly installed, a house ﬁre may result. To reduce the risk of ﬁre, follow the installation instructions. Contact

local building or ﬁre ofﬁcials or authority having jurisdiction about restrictions, installation inspection and

permit requirements in your area.

2) CAUTION: Never use gasoline or gasoline-type lantern fuel, kerosene, charcoal lighter ﬂuid, or similar liquids to

start or “freshen up” a ﬁre in this heater. Keep all such liquids well away from heater while it is in use.

3) During operation, if any part of the stove starts to glow, the stove is in an overﬁred condition. Close the air controls

completely until the glowing has stopped. OVERFIRING VOIDS YOUR WARRANTY!

4) Cool ashes should be disposed of carefully, using a metal container.

5) Do not burn wet or green wood. Store wood in a dry location.

6) DO NOT BURN GARBAGE OR FLAMMABLE FLUIDS SUCH AS GASOLINE, NAPHTHA OR ENGINE

OIL. Do not burn treated wood, or wood with salt (driftwood, etc.). Burning materials other than wood

(including charcoal) under adverse conditions may generate carbon monoxide in the home, resulting in

illness or possible death.

7) Do not permit creosote or soot to accumulate excessively in the chimney or inside the ﬁrebox.

8) Check your chimney system thoroughly when installing into an existing metal or masonry chimney. Seek

professional advice if in doubt about its condition.

9) Do not connect this unit to a chimney ﬂue already serving another appliance.

10) Comply with all minimum clearances to combustibles as shown in this manual for this appliance.

11) Build ﬁre on brick ﬁrebox ﬂoor. Do not use grates, andirons or other methods to support fuel.

12) HOT WHILE IN OPERATION! Keep children, pets, clothing and furniture away. Contact can cause skin burns.

13) Do not connect to any air distribution duct or system

14) RISK OF FIRE! Do not operate with stove door open, without the ﬁrescreen, or ash removal system door open.

15) For further information refer to NFPA 211 (USA) or CAN/CSA-B365 (Canada).

16) Do not operate without fully assembling all components. Burning your stove without the legs attached (if supplied

with unit) will void your warranty, and could present a serious safety hazard

17) Do not oeprate with broken glass..

1445 North Highway

Colville, WA 99114-2008

1 2 3 4 5 6 ... 27 28

Summary of Contents

Page 1 - Isle Royale

SAVE THESE INSTRUCTIONSwww.quadraﬁre.com This manual contains instructions for Installation, Operation & Maintenance.Please read this entire manu

Page 2

RPage 10February 4, 2005Isle Royale Wood Stove250-5763BThimble Assembly:12" (305mm) of brick separation between clay liner and combustibles.Firec

Page 3 - TABLE OF CONTENTS

Page 11Isle Royale Wood StoveRFebruary 4, 2005250-5763BSOLID PACK CHIMNEY WITH METAL SUPPORTS AS A THIMBLEFigure 11ACenter of HoleWallCenter LineOpeni

Page 4 - LISTINGS and SAFETY NOTICES

RPage 12February 4, 2005Isle Royale Wood Stove250-5763BFirst, make the frame for the thimble, ensuring it is no smaller than 14 inches (356mm) sq

Page 5 - VENT SPECIFICATIONS:

Page 13Isle Royale Wood StoveRFebruary 4, 2005250-5763BCONNECTION TO A MASONRY FIREPLACEThere are several kits available to connect the stove to a

Page 6

RPage 14February 4, 2005Isle Royale Wood Stove250-5763BWhen a metal prefabricated chimney is used, the manufac-turer’s installation instructions must

Page 7 - LOCATING YOUR STOVE

Page 15Isle Royale Wood StoveRFebruary 4, 2005250-5763BSpark Arestor CapRoof FlashingStorm CollarJoist Shield/FirestopListed Chimney ConnectorFloor Pr

Page 8 - Material

RPage 16February 4, 2005Isle Royale Wood Stove250-5763BOUTSIDE AIR TERMINATION CAP(contains rodent screen)FLEX FLANGE1. Remove all materials from pac

Page 9

Page 17Isle Royale Wood StoveRFebruary 4, 2005250-5763BBURNING PROCESSIn recent years there has been an increasing concern about air quality. Much of

Page 10 - not too large

RPage 18February 4, 2005Isle Royale Wood Stove250-5763B WARNING! DO NOT LEAVE THE FIRE UNATTENDED WHEN THE DOOR IS UNLATCHED OR WHEN USING THE FIRES

Page 11 - Isle Royale Wood Stove

Page 19Isle Royale Wood StoveRFebruary 4, 2005250-5763BOPERATING INSTRUCTIONS (Cont’d)OPACITYThis helps to determine how cleanly your stove is burning

Page 12

RPage 2February 4, 2005Isle Royale Wood Stove250-5763Band Welcome to the Quadra-Fire Family!Hearth & Home Technologies welcomes you to our tradi-t

Page 13 - Figure 13A

RPage 20February 4, 2005Isle Royale Wood Stove250-5763BOPERATING INSTRUCTIONS (Cont’d)WOOD SELECTION AND STORAGEBurn only dry seasoned wood! This wil

Page 14

Page 21Isle Royale Wood StoveRFebruary 4, 2005250-5763BCHIMNEY CLEANING1. Remove all ash from the ﬁrebox and extinguish all hot embers before dispos

Page 15 - IN SLEEPING ROOM

RPage 22February 4, 2005Isle Royale Wood Stove250-5763BNOTE: Remove all labels from glass prior to lighting the ﬁrst ﬁre.GLASS CARE 1. Ensure tha

Page 16

Page 23Isle Royale Wood StoveRFebruary 4, 2005250-5763BDOOR & GASKETPeriodically check the door gasket for proper seal. As the gasket compresses

Page 17

RPage 24February 4, 2005Isle Royale Wood Stove250-5763B29282726252423222120191817161514131211109876543211 Bafﬂe Assembly 11 Grate 21 Rear2 Bafﬂe Fille

Page 18 - HAZARD TO YOUR HOME

Page 25Isle Royale Wood StoveRFebruary 4, 2005250-5763BService Parts Serial No. Part No.Brick Set 834-3860Brick, single (See page 23 for dimensions) 8

Page 19

RPage 26February 4, 2005Isle Royale Wood Stove250-5763BDate of Service Performed By Description of ServiceService and Maintenance Log

Page 20

Page 27Isle Royale Wood StoveRFebruary 4, 2005250-5763BLifetime WarrantyLIMITED LIFETIME WARRANTYThe Hearth & Home Technologies limited Lifetime W

Page 21 - ASH REMOVAL & DISPOSAL

RFebruary 4, 2005Page 28• Do NOT discard this manual.• Important operating and maintenance instructions included.• Read, understand and follow thes

Page 22 - MAINTENANCE (CONT'D)

Page 3Isle Royale Wood StoveRFebruary 4, 2005250-5763BListings & Safety Notices ...3Serial Number Label Locat

Page 23 - MAINTENANCE

RPage 4February 4, 2005Isle Royale Wood Stove250-5763BLISTINGS and SAFETY NOTICESWARNING ! DO NOT ATTEMPT TO OPERATE THIS WOODSTOVE WITHOUT READING

Page 24

Page 5Isle Royale Wood StoveRFebruary 4, 2005250-5763BDIMENSIONSFRONT VIEWSIDE VIEW29" (737mm)28-3/4" (730mm)30" (762mm)CL8-1/4" (

Page 25

RPage 6February 4, 2005Isle Royale Wood Stove250-5763BBACDCLEARANCES TO COMBUSTIBLES (UL and ULC)GHCeilingEEFFMINIMUM CLEARANCES TO COMBUSTIBLE MATERI

Page 26

Page 7Isle Royale Wood StoveRFebruary 4, 2005250-5763BFLOOR PROTECTIONThe floor must be non-combustible material, extending beneath heater and t

Page 27 - Lifetime Warranty

RPage 8February 4, 2005Isle Royale Wood Stove250-5763BREVERSIBLE FLUE COLLARThe ﬂue collar is reversible for either a top or rear venting installation

Page 28 - Your Records for Model:

Page 9Isle Royale Wood StoveRFebruary 4, 2005250-5763BTo be sure that your stove burns properly, the chimney draft (static pressure) should be approxi

Comments to this Manuals

No comments

Quadra-Fire Isle Royale User Manual

Browse online or download User Manual for Fireplaces Quadra-Fire Isle Royale. Quadra-Fire Isle Royale User's Manual

Summary of Contents

Comments to this Manuals

Related products and manuals for Fireplaces Quadra-Fire Isle Royale